Weil-McLain WM97+70 Specifications Page 135
- Page / 136
- Table of contents
- TROUBLESHOOTING
- BOOKMARKS
Rated. / 5. Based on customer reviews
Part number 550-142-120/0113
– 135 –
WM97+ gas-fired water boiler — Boiler Manual
Boiler Start-Up Data
Boiler Model / Series WM97+ ________ / Series ____ Date installed ________________ CO
2
@: High fire ______% Low fire ______%
CP Number ____________ FUEL: Natural ____ LP ____ Btu Input ___________________ CO @: High fire ____ ppm Low fire ____ ppm
Flame signal on control display at high fire __________________ Flame signal on control display at low fire __________________
Was orifice changed? _________ Was gas valve throttle adjusted? ______ Natural gas input rate measured HIGH________ CFH / LOW________ CFH
WM97+ control SET-UP DATA
BOILER Settings HEAT Settings DHW Settings (if installed) CWH Settings (if installed)
Boiler Model WM97+ ________ System Type DHW OFF ___ ON ___ DHW OFF ___ ON ___
High Altitude Yes ____ NO ____ Boiler Circ Speed
HIGH __ MED __ LOW __OFF __
Boiler Circ Speed
HIGH __ MED __ LOW __OFF __
Boiler Circ Speed
HIGH __ MED __ LOW __OFF __
Manual Reset Temp °F Max Supply °F Boiler Supply °F Boiler Supply °F
WWSD Temp °F Min Supply °F
Adjust Outdoor °F Max Outdoor °F
Circulator Exercising
Min Outdoor °F
Circulator 1: On ___ Off ___ Modulate On Diff °F Modulate On Diff °F Modulate On Diff °F
Circulator 2: On ___ Off ___ Modulate Off Diff °F Modulate Off Diff °F Modulate Off Diff °F
Circulator 3: On ___ Off ___ Min On Time minutes Max On Time minutes Max On Time minutes
Boiler circ: On ___ Off ___ Boost Interval minutes
Freeze Protection
Pre-pump Time: seconds Pre-pump Time: seconds Pre-pump Time: seconds
Circulator 1: On ___ Off ___ Post-pump Time: seconds Post-pump Time: seconds Post-pump Time: seconds
Circulator 2: On ___ Off ___ Maximum Rate RPM Maximum Rate RPM Maximum Rate RPM
Circulator 3: On ___ Off ___ Minimum Rate RPM Minimum Rate RPM Minimum Rate RPM
Boiler circ: On ___ Off ___
CERTIFIED THAT: Installation instructions have been followed.
Check-out sequence has been performed.
Above information is certified to be correct.
Information received and left with owner/maintenance person.
Installer
(Company) (Address) (Phone) (Installer's Signature)
Installation and Service Certificate
- Boiler Manual 1
- Contents 6
- Please read before proceeding 7
- Boiler location 8
- Boiler location (continued) 9
- Wall-mounting the boiler 10
- (continued) 11
- Boiler hydrostatic test 12
- (see legend at right) 13
- (see legend below) 13
- Part number 550-142-120/0113 14
- (cont.) 15
- Gas piping — sizing gas lines 18
- Venting/air piping — general 19
- Vent termination requirements 23
- Boiler room air openings 24
- Sidewall with separate pipes 27
- Sidewall concentric 29
- Vertical with separate pipes 31
- Vertical concentric 33
- Prepare roof penetrations 34
- Mount concentric termination 34
- USE SWEEP ELBOWS FOR ALL 36
- VENT AND AIR PIPING — DO NOT 36
- Install water piping 37
- WM97+70 or 110 only 40
- WM97+155 only 41
- Existing expansion tanks 42
- Expansion tank — WM97+155 43
- System piping (continued) 45
- Multiple boiler installations 56
- Install condensate line 62
- Gas piping 63
- Field wiring 64
- Field wiring (continued) 65
- Wiring diagram — schematic 67
- Wiring diagram — ladder 68
- ONLY if the system meets the 69
- WM97+ control operation 71
- WM97+ control settings 74
- BOILER SETTINGS menus 75
- HEAT SETTINGS menus 77
- DHW SETTINGS menus 80
- CIRCULATOR EXERCISING and 82
- DIAGNOSTIC menu 83
- DIAGNOSTICS menu (continued) 84
- MAINTENANCE INFO 86
- Startup — fill the system 87
- Freeze protection (if used) 88
- Startup — final checks 89
- 70 or 110 89
- Check water piping 90
- Check gas piping 90
- Check-out/startup verification 94
- Owner maintenance 95
- Service technician 95
- Annual startup 96
- Annual startup (continued) 100
- Troubleshooting 102
- Troubleshooting (continued) 103
- Maintenance 110
- Inspect and clean the burner 112
- Tools required 112
- Before proceeding: 112
- Cleaning the WM97+155 heat 115
- Replacement parts 118
- Replacement parts (continued) 119
- Dimensions 132
- Ratings — WM97+ boilers 133
- HIGH __ MED __ LOW __OFF __ 135
- HIGH __ LOW __ MED __OFF __ 136
Related products and manuals for Water heaters & boilers Weil-McLain WM97+70
(29 pages)© 2020, manymanuals.com. All rights reserved. | 0.705 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals